MANUAL SUPPLEMENTS
- Air cleaner, K&N
- Aluminum trunk pictures
- Alternator dimensions
- Alternator wiring (with dash indicator)
- Alternator wiring for SOHC engine
- Antifreeze - What color?
- Antifreeze mixtures
- Battery faqs, general
- Battery, trunk mounted
- Bell housing alignment
- Body
details
paint stripes
emblems - Body shop, prep for
- Brakes
Bedding pads and rotors (Wilwood page)
Brake balance bar adjustment
Fluid specifications
Replacing the brake fluid (flushing) Squeal (Sierra calipers)
Brake light switch, updating
Updating the master cylinders
VW master cylinder service
Wilwood Pad Selection for Sierra calipers - Brake service, Jag
- Carburetor linkage
- Carpet installation pictures
- Charging system
- Chassis number
- Clutch
Pressure plate bolt circle patterns
Release system - concentric throwout bearing
Slave cylinder installation
Troubleshooting - Colors, original paint
- Cooling system hose trim update
- Door Pull-strap installation
- Driveshaft drawings (PDF)
- Electrical troubleshooting
- Electrolysis (of aluminum)
- Engine block and head casting numbers
- Engine mount mods, FE
- Engine mount mods, SB Ford
- Engine internal speciifications
- ERA rear suspension alignment
- ERA rear suspension retrofit
- Fender chip protection with Invinca-shield
- Fender spats, Installing
- Front fan installation
- Front wheelwell vents
- Fuel gage inaccuracies
- Gearing, differential/trans
- Headlight plug
- Heat past door hinge
- Hood rivets and scoop
- Hose trim update page
- Hot start problems
- Hurst shift linkage adjustment
- Ignition problems, troubleshooting
- Insurance
- Jag-based
rear suspension
Axle/hub-bearing adjustment
Brake caliper (including handbrake) service
Damper specifications
Differential ratcheting noise around sharp corners: See Lubrication in the manual.
Hub lower-pivot-bearing adjustment
Grease fittings (half-shaft) Mounting dimensions
Pinion seal replacement
Parts list
Remove and replace assembly
Trailing arm (early)
Wheel hop under hard accelleration
Heavy duty parts from CWI - Motor mount modifications
- MSD troubleshooting
- MSD/Stewart Warner tach problems
- Oil line routing, with and without remote filter
- Oil pans (link to Canton)
- Oil pan - max dimensions
- Oil pressure (low) on a Center-oiler FE
- Oil pressure line onto small block engine
- Oil pressure line, Replacing plastic with copper (S/W gage only)
- Paint colors
- Painting preparation
- Rear-mounted battery
- Rear
Suspension, ERA
Alignment
Retrofitting into an early chassis - Rear
Suspension, Jag-based
(see "Jag..." above)
Registration and titling - Relay (fan and horn) connections
- Retrofitting the aluminum radiator
- Roll bar installation template (zipped file)
- Rug installation pictures
- Sealing the door hinge area
- Seat belt mounting dimensions
- Shift lever to Hurst shifter
- Shift linkage adjustment (Hurst)
- lutch
- Signal lights - See "Wiring"
- Slave cylinder installation, c
- Soft top, Fitting
- Spats, Installing
- Speedometer
cable connection, TKO 600
Cable Routing - Speedometer gear selection
- Squeaking (brakes) in front
- Starter (Tilton) setup
- Steering column bushings
- Steering column, early (Datsun rack)
- Stripe dimensions
- Tail light reflector drawing
- Thermostat modifications
- Throttle
linkage
Turkey pan - Tilton starter setup
- Tires
Balance
Recommended sizes for ERA cars - Transmission gearing
- Vents, Front wheelwell
- Wiring
*New! A preliminary wiring "primer" and troubleshooting guide.
Alternator connections and basic alternator schematics
Alternator wiring for the SOHC
Brake lights
Charging - Troubleshooting Emergency flashers
Fans, Troubleshooting the radiator
Fan relay Headlight plug Horn relay Ignition problems, troubleshooting Unilite(Mallory) testing
MSD Installation
MSD Troubleshoting
Quad tail lights (Amber/red)
Signal and headlight switch hookup
Signal troubleshooting
Starter button, adding
Starter with integral solenoid
Stewart Warner/MSD problems
Tachometer (Caerbont) wiring
Tachometer (Nisonger) wiring
Tail lights, Amber/red quad
Troubleshooting brake and signal lights
VW headlight/signal switch wiring schematic
